| Body Tub | Full Fiberglass Tub from US Body Source {3} |
| Front Clip | One Piece 73-80 (Stock hood) tilt Front Clip |
| Rear Axle | 14 Bolt Full Float 10.5" Ring Gear Detroit Locker w/TSM Rear Disc Conversion {1} |
| Rear Rotors | 80-90 Ford 3/4 Front rotors (Enlarged stud holes to accept stock GM studs) |
| Rear Calipers | 76-78 Cadillac Eldorado Rear Calipers w/e-brake |
| Front Axle | Dana 44 (orig 1/2 ton. conv to 3/4 ton) 3/4 ton |
| Front Rotors | 75 Chevy 3/4 4x4 front rotors |
| Front Calipers | 75 Chevy 3/4 (1/2 is same?) |
| Front Shackles | Off-Road Design {2} HD models |
| Braking System | Assist Unit: 1997
K2500 Hydroboost Unit, custom push rod Master Cylinder: GM Master Cylinder from 1997 K3500 w/rear disc brakes Lines: Stainless Steel Brake Lines {4} Rear Rotors: 80-90 Ford 3/4 Front rotors (Enlarged stud holes to accept stock GM studs) Front Rotors: 75 Chevy 3/4 4x4 front rotors Rear Calipers: 76-78 Cadillac Eldorado Rear Calipers w/e-brake Front Calipers: '75 Chevy 3/4" ton (1/2 ton is same) |
| Fuel Line | Stainless Steel Fuel Line {4} |
| Fuel Tank | 48Gal From Unknown Origin. (On vehicle upon purchase) |
| Sway Bar | Stock w/ Off-Road Design {2} Sway Bar Correction/Disconnect Kit |
| Steering Braces | Off-Road
Design {2} Bolt-in Brace kit JC Whitney Frame Brace Kit (Welded) |
| Steering Column | 1984 Manual Trans, tilt column w/Cruise &
intermittent wiper Ground second "flat" into second D to fit standard 1" DD ujoint for shaft |
| Steering Shaft | Borgeson Upper Joint: 1"DD-1"DD Joint Lower Joint: 3/4"DD-13/16" 36Spline Joint Shaft: Collapsable 1"DD-3/4"DD |
| Transfer Case | NP205. Refurbish w/New bearings |
| Transmission | SM465 (4sp w/granny low) Refurbished with new Bearings/shift Fork. |
| Roll Cage | 2"O.D. 1/8"wall Steel tubing. 8pts to Frame. Custom Bent & Welded. |
| Doors | New 73-76 P/U doors Modified for 73-75 Blazer Style by cutting rear post & installing orig. reinforcment |
| FBHP Reinforment | NOS {GM} FBHP Reinf. cut in half, cut off flanges. |
| Door Hinges | New {GM} Upper. Rebuilt Lower Door Hinges w/new {GM} Pins/bushings |
| Tailgate | New {GM} 73-91 Blazer Tailgate. |
| Tailgate Glass | Used Privacy {GM} |
| Tailgate Hinges | New {GM} |
| Taillights | New {GM}. Lens & Housing & Gasket |
| Parklights | New {GM} Lens & Gasket. Refurbished Housing. |
| Heater | Used NonAC heater case inr/controls. from 1980's Truck (no
internal vent under dash) New {GM} HD heater Case Outer. New {GM} HD Heater Switch & Resistor New Heater Core {Local Parts Store} New HD Blower Motor/Fan |
| Grille | NOS{ GM} 1973 Grille NOS {GM} 350 Emblem NOS Headlight Bezels NOS Upper/Lower Grille Mouldings |
| Fuel Filter EFI High Pressure | Acell 74720 or GM 25171792 or AC GF652 - Takes Accell 74721 Saginaw 3/8 orig to -6 AN Fittings |
| Radiator | Flex-a-Lite 57000 or 57294 (29 is Fan kit). Fans are Flex-a-lite 294 15" 6000cfm |
| Alternator |
Delco (Delphi) 15845338 145amp
PLFS style 2005-2007 Various GM trucks |
| Starter |
Delco 9000786 From 1999-2001
Chevy trucks with 5.7L Mini high torque gear reduction permenent magnent |
| Inverter |
Go Power! GB500-SB 500w Inverter
w/10amp Charger http://www.gpelectric.com |
| Headers |
Heddmen 69830 Coated |
| Mufflers |
Dynomax Ultra-Flow 17289
Stainless Steel |
Reference Section:
(1) TSM (The StreetRod Manufacturer)
4321 Willow Creek Road
Castle Rock, CO 80104
tsmmfg@aol.com
phone 303-688-6882
(2) Off-Road Design
314 County Road 110, #2
Glenwood Springs, CO 81601
970.945.7777
Email:tech@offroaddesign.com
URL:
http://www.offroaddesign.com
(3) US Body Source
URL: http://www.usbodysource.com
(4) Inline Tube
33783 Groesbeck Hwy.
Fraser, Michigan 48026
Order Line:
800.385.9452
Tech Support:
586.294.4093
24 Hour Fax:
586.294.7349
URL: http://www.inlinetube.com
{GM} - GM Part
Numbers
Right/Common Left
Shell,
Tailgate
15614462
Glass, Rear Gate
Privacy
15531501
Reinf, Hinge
Pillar
377786
377785
Hinge, Assy Door
Upper
14000094 14000095
Pin,
Hinge
6271989
Bushing, Hinge
Pin
Inquire
Hinge, Assy Tailgate
Mdl Upr
Grille
361117
Mdl Lwr
Grille
361118
Bezel HeadLamp Door
Right
376627
Lens Park Lamp
w/Trm
5965288 5965287
gasket Park Lamp Lens/Housing 5964329
Lens Tail Lamp
w/Trm
5968330 5968329
Housing Tail
Lamp
5965772 5965771
Gasket Tail Lamp Lens/Housing 5965748
Cylinder,
Master
18092270
Misc Clutch Parts:
|
Quantity |
PART NO. |
DESCRIPTION |
PRICE |
EXT. PRICE |
CORE |
TOTAL |
STATUS |
Tracking # |
|
|---|---|---|---|---|---|---|---|---|---|
|
1 |
*15506879 |
BOOT ASM |
$12.45 |
$12.45 |
$0.00 |
$12.45 |
In Process |
|
|
|
1 |
*340690 |
ROD |
$4.79 |
$9.58 |
$0.00 |
$9.58 |
In Process |
|
|
|
1 |
*335380 |
SWIVE |
$6.43 |
$6.43 |
$0.00 |
$6.43 |
In Process |
|
|
|
1 |
*326550 |
SEAL-CLUT |
$2.23 |
$2.23 |
$0.00 |
$2.23 |
In Process |
|
|
|
Taxes: |
$0.00 |
||||||||
|
Handling and Shipping: |
$11.61 |
||||||||
|
ORDER TOTAL: |
$42.30 |
||||||||
|
Quantity |
PART NO. |
DESCRIPTION |
PRICE |
EXT. PRICE |
CORE |
TOTAL |
STATUS |
Tracking # |
|
|---|---|---|---|---|---|---|---|---|---|
|
1 |
*6264935 |
ROD |
$39.84 |
$39.84 |
$0.00 |
$39.84 |
Shipped DHL |
|
|
|
1 |
*3750696 |
SPRING |
$0.61 |
$15.25 |
$0.00 |
$15.25 |
Shipped DHL |
|
|
|
1 |
*3866568 |
STUD |
$7.51 |
$15.02 |
$0.00 |
$15.02 |
Shipped DHL |
|
|
|
1 |
*326581 |
STUD-CLUT |
$14.64 |
$14.64 |
$0.00 |
$14.64 |
Shipped DHL |
|
|
|
1 |
*6261873 |
SEAT |
$0.75 |
$7.50 |
$0.00 |
$7.50 |
Shipped DHL |
|
|
|
1 |
*6264937 |
BOOT ASM |
$6.02 |
$6.02 |
$0.00 |
$6.02 |
Shipped DHL |
|
|
|
1 |
*3968668 |
BUSHING |
$0.75 |
$3.75 |
$0.00 |
$3.75 |
Shipped DHL |
|
|
|
1 |
*326580 |
RETAINER |
$3.45 |
$3.45 |
$0.00 |
$3.45 |
Shipped DHL |
|
|
|
1 |
*382658 |
SEAL |
$2.33 |
$2.33 |
$0.00 |
$2.33 |
Shipped DHL |
|
|
|
Taxes: |
$0.00 |
||||||||
|
Handling and Shipping: |
$26.46 |
||||||||
|
ORDER TOTAL: |
$134.26 |
||||||||